Material Safety Data Sheet

5S-Road Stabilizer

1. Identification of Substance/Preparation and Company:

Product Name: 5S-ROAD

○

○ Main Use: Road Construction

○ Company: 5S – Sand Soil Stabilization Smart Solutions ,Dammam, Saudi Arabia

2. Composition / Information on ingredients

○ Chemical Nature: Water based dispersion of synthetic polymers with additives

○ Hazardous Components: None according to EU directive 1999/45/EC

3. Hazards identification:

○ Critical hazards to man and the environment: None according to EU directive 1999/45/EC

4. First Aid measures:

○ Eye contact: May cause temporary irritation. Irrigate with water for 15 minutes holding eyelid open. Seek medical attention if irritation persists.

○ Skin contact: Prolonged contact may cause irritation. Remove contaminated clothing. Wash thoroughly with soap and water Seek medical attention if symptoms persist.

○ Inhalation of vapour: Remove to fresh air in severe cases seek medical attention.

Ingestion: May cause nausea. Seek immediate medical attention Do not induce vomiting.

5. Firefighting measures

○ Hazards during fire-fighting: The product is water based and is not combustible.

6. Handling and Storage:

Handling:

○ No special precautions necessary.

○ Observe good housekeeping practice.

○ Keep workplace well ventilated.

Storage:

○ Store between +5°C and +45°C protected from frost and direct sunlight.

○ Do not use storage vessels or pipework made of aluminium, copper or their alloys.

○ Detailed advice on storage systems can be provided.

○ Bulk tanks should be regularly cleaned and sterilized.

Level 21 Khobar Gate Tower |

King Fahad Road | PO Box

32348 Khobar 31952, KSA

www.5S-Tech.Org

+966 13 330 8542

Page 1 of 3

Material Safety Data Sheet

5S-Road Stabilizer

7. Exposure controls / personal protection

○ General protective measures: The product may contain low levels of volatile organic compounds or ammonia which may evaporate during application and drying.

○ Advice on system: Provide good general ventilation in the workplace. Where design the product is dried or sprayed, local extraction is recommended.

○ Components with workplace parameters: none according to EU directive 1999/45/EC

○ Personal protective equipment:

● Respiratory: If spraying product without local exhaust ventilation, protection wear mask respirator with a charcoal cartridge.

● Hand protection: Impermeable gloves recommended.

● Eye protection: Eye protection recommended.

● Skin protection: In case of severe splashing wear waterproof overalls and boots. Wash with soap and water after handling.

● Hygiene measures: Do not eat, drink or smoke when handling product.

8. Physical and chemical properties

○ Physical form: liquid

○ Colour: white

○ Odour: faint aromatic

○ Flash point: not applicable

○ Vapour pressure: 23 hPa @ 20°C

○ Relative density: 1.00 +/-0.1

○ Solubility in water: insoluble but miscible in all proportions

○ pH: 6 +/- 0.5

○ Viscosity: <1000 mPa s

9. Stability and Reactivity

○ The product is stable under recommended storage conditions - see Section 7

○ Incompatible: None

10. Toxicological information

○ Long term experience of this product type indicates no danger to health when properly handled under industrial conditions

11. Transport information

○ The product is not classified as Dangerous for Transport.

Level 21 Khobar Gate Tower |

King Fahad Road | PO Box

32348 Khobar 31952, KSA

www.5S-Tech.Org

+966 13 330 8542

Page 2 of 3

Material Safety Data Sheet

5S-Road Stabilizer

12. Ecological information

○ Degradation/elimination: DOC elimination after 2 days (OECD302B): 98 %

○ The product can be virtually eliminated from water by biotic processes, e.g. adsorption onto activated sludge.

○ Bioaccumulation: No evidence of bioaccumulation.

○ Ecotoxic effects: The product is not classified as Dangerous for the Environment.

13. Accidental release measures

○ Personal protection: Refer to section 8.

○ Environmental Precaution: Prevent product entering soil, natural waters and drains.

14. Disposal considerations

○ Waste product should not be discharged directly into drains or waterways without treatment.

○ Disposal of product and packaging should always comply with local and national regulations.

○ Waste water containing product should be treated in a separation and biological treatment plant.

15. Regulatory information

○ Labelling according to EU directive 1999/45/EC:

○ Symbol not subject to labelling.

○ National regulations:

● Germany: Water hazard

● Class: WGK = 1, VwVwS Annex 4

16. Other information

○ The information given here is to the best of our knowledge true and accurate and is provided solely for making safety assessments. It is not a sales specification or an indication of suitability for a particular use.

○ 5S-ROAD is manufactured in Saudi Arabia according to the formulations and specifications of 5S